Harley Davidson Forums
0 2018/09/17 13:29:00
0 2018/12/08 02:53:48
CD Lighted windshield bar w/turn signals, Cirius LEDs on the crash bar canted out 30 degrees, Custom Dynamics turn signals, homemade LEDs in the vent (they fire sideways = forward), driving lights flashed on with high beam.
CD Lighted windshield bar w/turn signals, Cirius LEDs on the crash bar canted out 30 degrees, Custom Dynamics turn signals, homemade LEDs in the vent (they fire sideways = forward), driving lights flashed on with high beam.
0 2018/12/27 08:00:15
Lighted areowings and rack, Superbright tail lights, custom LED bar across below the bumper.
Lighted areowings and rack, Superbright tail lights, custom LED bar across below the bumper.
0 2018/12/27 08:00:18
Bumper light assembly detail
Bumper light assembly detail
0 2018/12/27 08:00:24
These are side-firing LEDs, so they aren't seen from anywhere but directly behind, but they point UP towards the tour pack, which reflects them as a bunch of little bright dots on it; but when you look, there aren't any lights there!
These are side-firing LEDs, so they aren't seen from anywhere but directly behind, but they point UP towards the tour pack, which reflects them as a bunch of little bright dots on it; but when you look, there aren't any lights there!
0 2018/12/27 08:00:28
0 2019/01/04 21:15:42
The rear fork.
The rear fork.
0 2019/02/15 09:19:51
How the fork attaches to the axle.
How the fork attaches to the axle.
0 2019/02/15 09:19:53
Before putting it down
Before putting it down
0 2019/03/01 16:10:45
From in the trailer
From in the trailer
0 2019/03/01 16:10:47
Threshold filler with anti-slip stuff from outside. Rear tie-downs (factory)
Threshold filler with anti-slip stuff from outside. Rear tie-downs (factory)
0 2019/03/01 16:10:48
Stored.
Stored.
0 2019/03/01 16:10:49
Cord and rope storage, vent, pass-through, passenger rear by door.
Cord and rope storage, vent, pass-through, passenger rear by door.
0 2019/03/01 16:14:23
Pass-through open inside
Pass-through open inside
0 2019/03/01 16:14:24
Pass-through sealed
Pass-through sealed
0 2019/03/01 16:14:26
Outside door of pass-through. Not intended for 75mph, hence the duct tape. Also use tape as a little 'roof' over the opening when the cord is passed through.
Outside door of pass-through. Not intended for 75mph, hence the duct tape. Also use tape as a little 'roof' over the opening when the cord is passed through.
0 2019/03/01 16:14:27
A magnetic light. Interestingly I tested one of these things to see how long the cheap, included AAA cells would last, so I could put fresh ones in. It wasn't very bright when I finally shut it off 56 hours later, but it was still going! I should have just kept those original batteries, lol!
A magnetic light. Interestingly I tested one of these things to see how long the cheap, included AAA cells would last, so I could put fresh ones in. It wasn't very bright when I finally shut it off 56 hours later, but it was still going! I should have just kept those original batteries, lol!
0 2019/03/01 16:14:28
Metal mending plates for . . .
Metal mending plates for . . .
0 2019/03/01 16:14:29
Spare tire holder; what can I say, I'm cheap. Saved $35 with some wood scraps and a bolt/nut. Pretty darned strong.
Spare tire holder; what can I say, I'm cheap. Saved $35 with some wood scraps and a bolt/nut. Pretty darned strong.
0 2019/03/01 16:14:31
The weight of the wheel/tire mostly sits on the holder. LOOSEN YOUR MOUNTS BEFORE ADDING AIR TO THE TIRE!!! Don't ask how I know...
The weight of the wheel/tire mostly sits on the holder. LOOSEN YOUR MOUNTS BEFORE ADDING AIR TO THE TIRE!!! Don't ask how I know...
0 2019/03/01 16:14:32
Clothes hangars for riding jackets, under layers and anything else we're taking along.
Clothes hangars for riding jackets, under layers and anything else we're taking along.
0 2019/03/01 16:25:51
The top piece keeps them from coming off during transit.
The top piece keeps them from coming off during transit.
0 2019/03/01 16:25:53
But swings out of the way to allow normal use.
But swings out of the way to allow normal use.
0 2019/03/01 16:25:54
0 2019/03/01 16:25:55
Here you can mostly see where I had to cut into the trailer body to get the weight distribution / sway control bar mounts on the frame. The distance to the ball center was a minimum of 27" and I only had 25.5. Only a small part of the body support frame (NOT the structural frame) and I filled that with some JB Weld. The duct tape was a temporary thing until I could make a better seal.
Here you can mostly see where I had to cut into the trailer body to get the weight distribution / sway control bar mounts on the frame. The distance to the ball center was a minimum of 27" and I only had 25.5. Only a small part of the body support frame (NOT the structural frame) and I filled that with some JB Weld. The duct tape was a temporary thing until I could make a better seal.
0 2019/03/01 16:25:57
A little closer look.
A little closer look.
0 2019/03/01 16:25:58
Storage for the larger flashlight and the bar used on the rear fold-down stabilizer jacks. I intend to add more for things like the folding tire iron, torque wrench and some other stuff.
Storage for the larger flashlight and the bar used on the rear fold-down stabilizer jacks. I intend to add more for things like the folding tire iron, torque wrench and some other stuff.
0 2019/03/01 16:26:00
Bigger picture. Note the added reflector material. I added a lot.
Bigger picture. Note the added reflector material. I added a lot.
0 2019/03/01 16:26:01
This will save your knees! Makes it a lot easier, works good at home, too.
This will save your knees! Makes it a lot easier, works good at home, too.
0 2019/03/01 16:34:53
A floor batten for some tubs that things like rags, wax, oil and other stuff can go in. Another one sits on that one for various travel supplies and things we need to take for rentals. Wall mount for the bungee cord to hold them from going anywhere.
A floor batten for some tubs that things like rags, wax, oil and other stuff can go in. Another one sits on that one for various travel supplies and things we need to take for rentals. Wall mount for the bungee cord to hold them from going anywhere.
0 2019/03/01 16:34:54
For tools that may be needed quickly, trailer things like locks for the hitch, spare screws, hooks, hold down straps, towing mirror.
For tools that may be needed quickly, trailer things like locks for the hitch, spare screws, hooks, hold down straps, towing mirror.
0 2019/03/01 16:34:56
Keeps the door from beating you up.
Keeps the door from beating you up.
0 2019/03/01 16:34:57
My own design spring-loaded wheel chocks.
My own design spring-loaded wheel chocks.
0 2019/03/01 16:34:59
More added reflector strips and reflectors. I'm paranoid, I know.
More added reflector strips and reflectors. I'm paranoid, I know.
0 2019/03/01 16:35:00
One wall brace to keep the tubs from moving back towards the trike fenders, and the other to keep them from going forward. Cleats on the floor to keep the bottoms from moving around. So the tubs sit down between the cleats, and the second top layer of them is stacked on. Then ropes are ran from the bottom, up and over the top tub, and back down. Likewise another rope goes around the tubs away from the walls. So the tubs can't really go anywhere.
One wall brace to keep the tubs from moving back towards the trike fenders, and the other to keep them from going forward. Cleats on the floor to keep the bottoms from moving around. So the tubs sit down between the cleats, and the second top layer of them is stacked on. Then ropes are ran from the bottom, up and over the top tub, and back down. Likewise another rope goes around the tubs away from the walls. So the tubs can't really go anywhere.
0 2019/03/01 17:40:42
The braces keep the top tubs from moving, whereas only using wall anchors and rope would allow them to shift up to 4 or 5 inches forward/backwards under heavy acceleration or braking.
The braces keep the top tubs from moving, whereas only using wall anchors and rope would allow them to shift up to 4 or 5 inches forward/backwards under heavy acceleration or braking.
0 2019/03/01 17:40:43
Room for four tubs on the driver side of the trailer, just ahead of the trike rear fender.
Room for four tubs on the driver side of the trailer, just ahead of the trike rear fender.
0 2019/03/01 17:40:45
The stuff in our Jeep. It's full. But our suitcase, clothes bags, food bags, backpacks, shoes, bass guitar and practice amp and a whole bunch of other stuff needs to go in there. Hence the mods for the trailer are needed.
The stuff in our Jeep. It's full. But our suitcase, clothes bags, food bags, backpacks, shoes, bass guitar and practice amp and a whole bunch of other stuff needs to go in there. Hence the mods for the trailer are needed.
0 2019/03/01 17:40:46
Reinforced beaver tail, anti-slip strips for the rears, floor and deck paint.
Reinforced beaver tail, anti-slip strips for the rears, floor and deck paint.
0 2019/03/20 20:57:05
When you click on links to various merchants on this site and make a purchase, this can result in this site earning a commission. Affiliate programs and affiliations include, but are not limited to, the eBay Partner Network.
© 2026 MH Sub I, LLC dba Internet Brands