Engine Temp sensor bad?
Thread Starter
|
Novice
Joined: Jun 2008
Posts: 22
Likes: 0
From: SW Penna.
Engine Temp sensor bad?
Guys, My 97 FLHTCI (EVO) has been acting up, I noticed as fall was approaching my idle speed would be at 12-1500 once in awhile on cold mornings, but it seemed to settle down after the motor came up to temp. Yesterday, however I did about 35 miles at 40-45 degrees (two lane commute, stop sign or traffic light every couple minutes) and the whole time the idle was 15-2200 rpm, and after I got into stop and go for a couple minutes, and the motor got good and hot, she finally settled down. Shut it off for 10 minutes and when I started back up, the idle went high again. It seems like it only settles down when the motor is real hot. I didn't notice this in the summer (bought it in July) I guess because the motor got hot quickly then.
HD manual says both the eng temp sensor and the intake air temp sensor affect idle speed - any advice? Also my parts manual calls out 32446-95 for the part # of the ETS, is this a good # or has this thing been improved over the years?
I'm probably just gonna change it out anyway, 11 years (but only 21,000 miles) is probably long a enough life for a sensor that sits in the top of an aircooled motor.
Anything else I could check out or look for? I don't have a breakout box for the ECM.
Thanks,
Bogey
HD manual says both the eng temp sensor and the intake air temp sensor affect idle speed - any advice? Also my parts manual calls out 32446-95 for the part # of the ETS, is this a good # or has this thing been improved over the years?
I'm probably just gonna change it out anyway, 11 years (but only 21,000 miles) is probably long a enough life for a sensor that sits in the top of an aircooled motor.
Anything else I could check out or look for? I don't have a breakout box for the ECM.
Thanks,
Bogey
Cruiser
Joined: Aug 2008
Posts: 113
Likes: 0
From: Tenn
I have been dealing with similar issues with my 96 ultra as far as the idle and high RPM's, but mine would run fine cold and idled higher than normal after it warmed up.
At 21K miles I would make every effort to replace the fuel filter located inside the fuel tank (if your bike if fuel injected). If you may take the same filter as me, $60.... temp sensor $95.
The fuel looked like mud when I removed my filter and dumped into a jar.
I'm on the road right now, but managed to find both after stopping at 3 different Harley shops. As soon as I get home I will be replacing both filter and sensor.
Getting inside the tank is pretty easy by removing 2 screws just inside the fueling cover and at the base of the counsel. This will reveal a plate with 10 screws that will open up the tank. You will see the fuel pump and filter and the lines going to both.
good luck,
At 21K miles I would make every effort to replace the fuel filter located inside the fuel tank (if your bike if fuel injected). If you may take the same filter as me, $60.... temp sensor $95.
The fuel looked like mud when I removed my filter and dumped into a jar.
I'm on the road right now, but managed to find both after stopping at 3 different Harley shops. As soon as I get home I will be replacing both filter and sensor.
Getting inside the tank is pretty easy by removing 2 screws just inside the fueling cover and at the base of the counsel. This will reveal a plate with 10 screws that will open up the tank. You will see the fuel pump and filter and the lines going to both.
good luck,
Advanced
Joined: Oct 2007
Posts: 90
Likes: 0
From: Dyersville, IA
I had a similiar issue with my 96 Electra Glide classic. Mine initially started as the idle on the bike was too low. After replacing the map sensor and temp sensor, I experienced the high idle problem. But now it is back to low idle when it is cold. I think I might check the fuel filter. Not sure if was ever change.
Cruiser
Joined: Aug 2008
Posts: 113
Likes: 0
From: Tenn
Well I'll tell ya one thing for sure... After changing the temp sensor and the fuel filter on my 96 EVO, it was like I had gained 10 to 15 hp. The bike is responsive, has more torque and actually has a nicer sound at idle.
Advanced
Joined: Nov 2006
Posts: 67
Likes: 0
From: Christiansburg Va.
This summer same thing on my 97 flhtcui. Took it to HD they said fuel filter then they
said fuel pump then they said fuel regalator then they said eng temp sensor. $600.00
and week later it turned out to be a bad wire going to the eng temp sensor.
said fuel pump then they said fuel regalator then they said eng temp sensor. $600.00
and week later it turned out to be a bad wire going to the eng temp sensor.
Trending Topics
Intermediate
Joined: Nov 2008
Posts: 49
Likes: 1
From: Iowa
My 98 had the problem with the high idle and it was the cylinder head temp sensor. Changed it a bingo ran great and idled where it should.
HD Forum Stories
The Best of Harley-Davidson for Lifelong Riders
7 Surprising Harley-Davidson Products that Are Not Motorcycles
Verdad Gallardo
8 Best Harley-Davidson Motorcycles Ever
Pouria Savadkouei
10 Worst Harley-Davidson Motorcycles Ever
Pouria Savadkouei
Killer Custom's Jail Break Is The Breakout That Refused to Blend In
Verdad Gallardo
Crazy Bunderbike Build Looks Amazing, But Is It Impossible to Ride?
Verdad Gallardo
Harley-Davidson Reveals Super Cool Cafe Racer Concept
Verdad Gallardo
Engraved Rebellion: Inside Bundnerbike's Glam Rock II
Verdad Gallardo
10 Motorcycles You Should Never Buy
Joe Kucinski
10 Things Harley-Davidson Needs to Fix in 2026
Verdad Gallardo
Thread
Thread Starter
Forum
Replies
Last Post
FXDBij
Ignition/Tuner/ECM/Fuel Injection
7
May 29, 2019 12:56 AM
genodgeno
Ignition/Tuner/ECM/Fuel Injection
0
Oct 13, 2010 02:42 PM
