Road tools
Thread Starter
|
Road Captain
Joined: Feb 2007
Posts: 696
Likes: 0
From: Charlotte
Road tools
I've been looking at this tool kit http://www.beza.biz/windzone/catalog/ek1hdand it has these items in it:
Locking pliers
Tire pressure gauge
Flashlight w/ Battery
3/8" Ratchet Driver
5/8" Spark plug socket
13/16" Spark plug socket
3/8" & 7/16" Open-ended wrench
1/2" & 9/16" Open ended wrench
5/8" & 3/4" Open ended wrench
10mm Combination wrench
9 Hex Keys/Allen Wrenches
7-piece Torx set (T-10 thru T-40)
Phillips #1
Phillips #2
Small Slotted
Large Slotted
Spark plug gap gauge
Electrical wire
Electrical tape
Spare turn / tailight bulb
I have many of these items but would need to get a few to make it complete.
For you road warriors out there, what is lacking in this collection?
Also, will a 1/4" ratchet do the job or should I just have a 3/8" and a reducer to 1/4" drive?
Thanks,
Locking pliers
Tire pressure gauge
Flashlight w/ Battery
3/8" Ratchet Driver
5/8" Spark plug socket
13/16" Spark plug socket
3/8" & 7/16" Open-ended wrench
1/2" & 9/16" Open ended wrench
5/8" & 3/4" Open ended wrench
10mm Combination wrench
9 Hex Keys/Allen Wrenches
7-piece Torx set (T-10 thru T-40)
Phillips #1
Phillips #2
Small Slotted
Large Slotted
Spark plug gap gauge
Electrical wire
Electrical tape
Spare turn / tailight bulb
I have many of these items but would need to get a few to make it complete.
For you road warriors out there, what is lacking in this collection?
Also, will a 1/4" ratchet do the job or should I just have a 3/8" and a reducer to 1/4" drive?
Thanks,
Banned
Joined: Jan 2007
Posts: 2,301
Likes: 4
From:
RE: Road tools
I would combine some things.
One good screwdriver with multiple tips.
carry a allen wrench to fit shifter, lights and primary.
carry tork bit for whatever normally a 10,15,27 (I think)
A wrench that fits rear axle nut and shocks.
pliers with cutters.
3/8 rachet stubby ext and 4". 3/8,7/16,1/2,9/16 deep socket and 3/8 down
to 1/4 adapter.
roll of black tape, 1/2 dozen 6 or 8 " plastic ties
test light and fuses.
flash light (harbor freight has a crankup one no batteries needed).
longer trips rubber tire plugs and a air compressor.
If you're really paranoid emergency repair belt.
find a safe place to wire tie a spare key just in case.
One good screwdriver with multiple tips.
carry a allen wrench to fit shifter, lights and primary.
carry tork bit for whatever normally a 10,15,27 (I think)
A wrench that fits rear axle nut and shocks.
pliers with cutters.
3/8 rachet stubby ext and 4". 3/8,7/16,1/2,9/16 deep socket and 3/8 down
to 1/4 adapter.
roll of black tape, 1/2 dozen 6 or 8 " plastic ties
test light and fuses.
flash light (harbor freight has a crankup one no batteries needed).
longer trips rubber tire plugs and a air compressor.
If you're really paranoid emergency repair belt.
find a safe place to wire tie a spare key just in case.
Road Master
Joined: Nov 2006
Posts: 808
Likes: 4
From:
RE: Road tools
..see.. lot's of possible combinations.
https://www.hdforums.com/searchpro.a...bmitbutton=+OK+
Later
https://www.hdforums.com/searchpro.a...bmitbutton=+OK+
Later
Cruiser
Joined: Apr 2006
Posts: 110
Likes: 0
From: Colorado
RE: Road tools
i carry a tubeless tire repair kit, small air compressor, spark plugwrench, xtra bulbs (headlamp, tail, turn signal) screwdriver, torx bits, cell phone and AAA RV Plus.
anything other then those issues and it's on a flatbed. with todays tech what really craps out ?
on my 48 indian and 66 shovel i carried an adj wrench,
screw drivers, bulbs electrical tape, hose clamps, xtra fuel line (gas siphon) hammer 3/8-7/8 (3/8 drive) sockets fix a flat and ph numbers of friends with trucks. or i pushed / hitched to nearest phone booth
anything other then those issues and it's on a flatbed. with todays tech what really craps out ?
on my 48 indian and 66 shovel i carried an adj wrench,
screw drivers, bulbs electrical tape, hose clamps, xtra fuel line (gas siphon) hammer 3/8-7/8 (3/8 drive) sockets fix a flat and ph numbers of friends with trucks. or i pushed / hitched to nearest phone booth
Trending Topics
Ultimate HDF Member
Joined: Jul 2006
Posts: 9,335
Likes: 13
From: MA
RE: Road tools
I have that tool kit and it's very nice. In addition I also carry a 6" extension for my 3/8" ratchet.
HD Forum Stories
The Best of Harley-Davidson for Lifelong Riders
7 Surprising Harley-Davidson Products that Are Not Motorcycles
Verdad Gallardo
8 Best Harley-Davidson Motorcycles Ever
Pouria Savadkouei
10 Worst Harley-Davidson Motorcycles Ever
Pouria Savadkouei
Killer Custom's Jail Break Is The Breakout That Refused to Blend In
Verdad Gallardo
Crazy Bunderbike Build Looks Amazing, But Is It Impossible to Ride?
Verdad Gallardo
Harley-Davidson Reveals Super Cool Cafe Racer Concept
Verdad Gallardo
Engraved Rebellion: Inside Bundnerbike's Glam Rock II
Verdad Gallardo
10 Motorcycles You Should Never Buy
Joe Kucinski
10 Things Harley-Davidson Needs to Fix in 2026
Verdad Gallardo
Extreme HDF Member
Joined: Sep 2006
Posts: 10,033
Likes: 29
RE: Road tools
Go over you bike and figure out what tools you need making a list as you go, then go to Harbor Freight or similar and put together your own tool kit. It will be more complete and may even cost a few bucks less in the end.
Ultimate HDF Member
Joined: Dec 2006
Posts: 7,773
Likes: 7
From: Central Oklahoma
RE: Road tools
