Electical issues
Thread Starter
|
Road Captain
Joined: May 2012
Posts: 536
Likes: 19
From: York Haven Pa
Electical issues
2011 FLHTK Ultra Limited
Pulled the bike out about 2 weeks ago on a warm day and took it for a spin. As soon as I got to 20 mph I lost my radio and dash lights. Turned around and went home. Tested the battery and stator and they are good. So I thought it was the Voltage Regulator. I replaced it and took it out yesterday and same thing. It only does it under load. I talked to my Indy and he suggested to check the grounds. I removed the battery and checked and cleaned and greased the grounds on the primary, the grounds just in front of the battery and the ground in the fairing. Still doing it.
Need some help on where to look next.
Thanks
Cfave
Pulled the bike out about 2 weeks ago on a warm day and took it for a spin. As soon as I got to 20 mph I lost my radio and dash lights. Turned around and went home. Tested the battery and stator and they are good. So I thought it was the Voltage Regulator. I replaced it and took it out yesterday and same thing. It only does it under load. I talked to my Indy and he suggested to check the grounds. I removed the battery and checked and cleaned and greased the grounds on the primary, the grounds just in front of the battery and the ground in the fairing. Still doing it.
Need some help on where to look next.
Thanks
Cfave
Last edited by cfave; Mar 15, 2024 at 10:20 AM.
Seasoned HDF Member
Joined: Apr 2011
Posts: 6,185
Likes: 2,134
From: W. Texas
If only the radio and dash light are being affected I'd be cking the connectors along with fuse connections for those circuits.
Does playing with the ing switch in different positions or wiggling the wiring duplicate the problem?
WP
Does playing with the ing switch in different positions or wiggling the wiring duplicate the problem?
WP
Last edited by WP50; Mar 15, 2024 at 11:40 AM.
Thread Starter
|
Road Captain
Joined: May 2012
Posts: 536
Likes: 19
From: York Haven Pa
all the dash lights go out, the check engine light comes on, the radio drops and the voltage meter pins to the right and stays there.
No codes come up and other than the voltage meter, when I come back down under 20 mph all the dashlights and the radio come back on.
No codes come up and other than the voltage meter, when I come back down under 20 mph all the dashlights and the radio come back on.
Stellar HDF Member
Joined: May 2006
Posts: 2,809
Likes: 4,140
From: NC
Interesting. Seems you are thinking speed is the trigger and not rpm? That would lead to the ecu but obviously an odd conclusion. Or maybe the wind turbulence is exposing a wiring issue.
Last edited by tngarren; Mar 15, 2024 at 12:44 PM.
Grand HDF Member
Joined: Jan 2012
Posts: 4,458
Likes: 2,877
From: Oklahoma
Needle all the way to the right..does that mean over 18 volts? Did you clean the plugs that go on the voltage regulator? Do you have a manual so you can check if there are a couple of grounds under the gas tank, toward the rear? No codes with all of this?
Grand HDF Member
Joined: Mar 2007
Posts: 4,922
Likes: 265
From: Deep in the heart of New Jersey
If the lights go out and the radio quits while the bike is still, while revving the engine, I would check the voltage regulator / wiring first. If it's putting out way over 14.7 volts, there maybe some sort of over voltage protection kicking in that shuts things off.,,
Seasoned HDF Member
Joined: Mar 2021
Posts: 18,278
Likes: 3,687
From: backwoods
Put meter on battery, rev engine up, should stop around 14.4 dc. Doesn't prove you don't have intermittent problem. I
Trending Topics
Seasoned HDF Member
Joined: Apr 2011
Posts: 6,185
Likes: 2,134
From: W. Texas
HD Forum Stories
The Best of Harley-Davidson for Lifelong Riders
7 Surprising Harley-Davidson Products that Are Not Motorcycles
Verdad Gallardo
8 Best Harley-Davidson Motorcycles Ever
Pouria Savadkouei
10 Worst Harley-Davidson Motorcycles Ever
Pouria Savadkouei
Killer Custom's Jail Break Is The Breakout That Refused to Blend In
Verdad Gallardo
Crazy Bunderbike Build Looks Amazing, But Is It Impossible to Ride?
Verdad Gallardo
Harley-Davidson Reveals Super Cool Cafe Racer Concept
Verdad Gallardo
Engraved Rebellion: Inside Bundnerbike's Glam Rock II
Verdad Gallardo
10 Motorcycles You Should Never Buy
Joe Kucinski
10 Things Harley-Davidson Needs to Fix in 2026
Verdad Gallardo
Seasoned HDF Member
Joined: Mar 2021
Posts: 18,278
Likes: 3,687
From: backwoods
I get the impression some stuff cuts out, but bike is still running. Which why it is at 18V volts. So wouldn't be switch.
