Magneti Marelli EITMS system issue
Thread Starter
|
6th Gear
Joined: May 2020
Posts: 12
Likes: 3
From: maine
Magneti Marelli EITMS system issue
Hi Guys I have a 1999 Road King Classic seems the rear cylinder is running cold (the bike is stone cold) and at start up the rear cylinder runs cold and the bike sputters at bit at mid to low throttle
however the bike pulls just fine. I suspect the engine temp sensor may be bad, Plugs are both clean and show no sings of fouling rear has spark Im thinking its a fueling issue.
Any ideas ?
however the bike pulls just fine. I suspect the engine temp sensor may be bad, Plugs are both clean and show no sings of fouling rear has spark Im thinking its a fueling issue.
Any ideas ?
Road Warrior
Joined: Oct 2006
Posts: 1,350
Likes: 46
Use a propane torch ( don't light it) stick it in the throttle body & open the torch up. if it smooths out, it could be the injector or a wiring issue. I had an injector go bad on my 99 Ultra a few years back, put 2 new ones in & had one of the new ones go bad a few months later. So I have an old one & a newer one in my bike. But my mileage has dropped & running black smoke on the left bank (cyl1 rear cylinder) so it may be time for some new ones again for me. But I have 130K miles on it.
Toby
Toby
Road Warrior
Joined: Oct 2006
Posts: 1,350
Likes: 46
it was several years ago from Bike Bandit, but I think they stopped carrying HD parts. I have done a search & have found nothing. But it uses what they call a side fill vs a top fill fuel injector. I am looking into some alternatives. Some Toyota's, Nissan's and Subaru's use the side fill. so it is a matter of the dimensions and flow rate. I hope to find out more since I think I may have to replace mine again, or at least the one with 130K miles on it.
Toby
Toby
Thread Starter
|
6th Gear
Joined: May 2020
Posts: 12
Likes: 3
From: maine
Should you need them again I found them today and have 2 new ones on the way very difficult to find Let me know i will send you the company name
Do you know where I can find a TPS sensor for this bike I keep coming up empty
Thanks !
Do you know where I can find a TPS sensor for this bike I keep coming up empty
Thanks !
Thread Starter
|
6th Gear
Joined: May 2020
Posts: 12
Likes: 3
From: maine
Hi I got them at SouthBay Fuel Injection in NY State: https://www.southbayfuelinjectors.co...SAAEgKnWPD_BwE
Trending Topics
Road Master
Joined: Jul 2010
Posts: 1,045
Likes: 102
From: Waukesha, WI
HD Forum Stories
The Best of Harley-Davidson for Lifelong Riders
8 Best Harley-Davidson Motorcycles Ever
Pouria Savadkouei
10 Worst Harley-Davidson Motorcycles Ever
Pouria Savadkouei
Killer Custom's Jail Break Is The Breakout That Refused to Blend In
Verdad Gallardo
Crazy Bunderbike Build Looks Amazing, But Is It Impossible to Ride?
Verdad Gallardo
Harley-Davidson Reveals Super Cool Cafe Racer Concept
Verdad Gallardo
Engraved Rebellion: Inside Bundnerbike's Glam Rock II
Verdad Gallardo
10 Motorcycles You Should Never Buy
Joe Kucinski
10 Things Harley-Davidson Needs to Fix in 2026
Verdad Gallardo
Southpaw Super Glide: A Left-Hand-Drive 1979 Harley FXE Built to Fit the Rider
Verdad Gallardo
Road Master
Joined: Jul 2010
Posts: 1,045
Likes: 102
From: Waukesha, WI
Fair word of warning, you will probably need to do a hot-cold idle reset on it after you're done, if you don't have a service manual it may be a good idea to get one.